Finicky BMW

Finicky BMW

This TSB applies to BMW vehicles equipped with the N63 engine produced up to 2-15-2009.

An affected N63 vehicle may intermittently exhibit any of the following conditions:

-          The engine is hard to start or may not start at all.

-          The engine runs rough and lacks or loses power.

-          A check control message “Engine Power Reduced” is displayed.

In these situations, if the key is cycled and the engine is restarted, it usually runs normally again.

The fault code 110001 (cylinder injection cut-out, pressure too low in the high pressure system) is stored in the DME.

Vapor lock in the fuel system could occur under certain engine operating conditions, which then would cause a drop in the low side fuel pressure.

If only “110001 cylinder injection cut-out” is stored, program the vehicle using ISTA/P2.33.1 or later.

The new DME software has a revised auxiliary fan control strategy and increases the low side fuel pressure at idle.

If other faults are stored related to the electric fuel pump control module (EKP), misfire, lean fuel trim, high or low fuel pressure regulation system faults, then complete the recommended test plans.

Note that ISTA/P will automatically reprogram and code all programmable control modules that do not have the latest software.

     

   Related items


  • LSPI: What you should know
    LSPI stands for low speed pre-ignition, an issue that is limiting the extent to which oems can use engine downsizing, here’s what you should... Read more
  • NGK provides BMW spark plug replacement advice
    Spark Plug specialist NGK has issued advice on plug replacement on BMW N43 and N53 engines which were fitted with ZKBR7A-HTU NGK spark plugs as original... Read more
  • Metal 3D printing: technology of the future for lighter and more compact engines
    A team of Renault Trucks engineers and designers is working on an additive manufacturing process – metal 3D printing – that is set to boost the performance of engines. Technology of the future is fast becoming a reality, as can be seen from the complex parts that have already been successfully tested inside a Euro 6... Read more
  • BMW Pulse
    A pulsing or droning noise may be heard from the front of the vehicle on 2012 7-series... Read more
  • High court to hear VW emissions group litigation request
    Harcus Sinclair UK Limited, a UK law firm specialising in large group litigation, has applied for a group litigation order in claims against VW, Audi, SEAT and Skoda arising out of the Volkswagen emissions scandal, which has affected 1.2 million cars in the UK alone. This is the first group litigation order sought in relation to the VW emissions scandal on behalf of UK... Read more
Comments
Login to post comments

MOD_LOGINREGISTER_LOGIN_TITLE

Remember Me